Hey these are some pretty sweet customs. It stinks that you hit this forum when everyone seems to be away and haven't got much feedback. I'll try to help...
BATMAN
- I would change the wording on Strategist to be a little more concise and less awkward: "After rolling for intiative and before anyone takes a turn, you may choose any Order Marker on any opponent's Army Card and that opponent must reveal it to you."
- Grapple Line 3 should start "Instead of moving normally..." to be more official.
- Points-wise I'd say 190 is a little expensive. I think Spider-Man would hand it to Batman in a fight. Spider-Man has a slightly better movement ability but a little worse special attack. However, Spider-Man's Spider Sense makes him incredibly hard to kill. Spider-Man's a 4/4 so worse than Batman's 5/5, but I think Spider Sense makes up for it. I'd say drop Batman to 170 because of Strategist.
CLAYFACE
-
I might say "above or below" instead of "higher or lower than" in Pliable Body but that's just personal preference.
-Points-wise, again in comparison to Spider-Man I think Peter wins. Drop of 10-20 points I'd say.
HAWKGIRL
-
Good all around. Officer is a bit awkward though I don't know much about her. Probably would have used Warrior or Protector, or Lawman if I wanted Officer but to stay in line with officials.
MAN-BAT
- I like Fly-By Attack, but it could be simplified a bit. "If Man-Bat did not use all his movement, he may finish moving after attacking." Ehh, it's still a little awkward.
- Points look good, maybe a tad bit (5-10) cheap because of his hit and run potential. You'd have to see how that plays out.
ROBIN
- Grapple Line should be Grapple Line 3 and "Instead of moving normally..."
- 70 still seems a bit high, but Acrobat is a good power. I think against anyone with a special attack, Robin is going to fall easily.
Hope that helps!